Remove mk8 door card 3dr drivers side

[Magicmushroom2005]

Hi

i need to remove my mk8 door card,  i have a vibration when Speakers on , top of the door somewhere

its just the window switch pack its hard to

remove i have unclipped the top but the bit by the armrest i cant pull out

 

thanks

[iantt]

Pain the ***** they are.

Once you've unclipped the nearest edge to you, you need to put a couple of wedges in-between switch pack and door card to force it away a little. Then lift up vertically both ends of switch pack. 

[Magicmushroom2005]

Thanks mate ill have a try again and post a update

[Eng_Ahmad1986]

I found this manual online to remove the window switch unit , hope this helps 🙂 

1165678427_501-11GlassFramesandMechanisms.pdf

[iantt]

29 minutes ago, Eng_Ahmad1986 said:

I found this manual online to remove the window switch unit , hope this helps 🙂 

1165678427_501-11GlassFramesandMechanisms.pdf 2.7 MB · 4 downloads

Well done , that shows exactly what I was describing about the wedges. 

[martinf64]

I've had this off twice and it was a pain each time...wish I had that pdf rather than doing it blind...saved for future reference, thanks Ahmad good find 👍

[Eng_Ahmad1986]

On 12/20/2020 at 6:46 PM, iantt said:

Well done , that shows exactly what I was describing about the wedges. 

 

19 hours ago, martinf64 said:

I've had this off twice and it was a pain each time...wish I had that pdf rather than doing it blind...saved for future reference, thanks Ahmad good find 👍

Thank you to both of you 😊😊

[robbyvrs]

Would it be easier to remove the door card instead or do you need to remove the switch panel to access fixings to remove the card?

[martinf64]

2 hours ago, robbyvrs said:

Would it be easier to remove the door card instead or do you need to remove the switch panel to access fixings to remove the card?

Gotta take switch panel off to access screws holding door card to the door unfortunately, its a right pain 😵

[robbyvrs]

21 hours ago, martinf64 said:

Gotta take switch panel off to access screws holding door card to the door unfortunately, its a right pain 😵

Ah - wasn't sure if there was a fixing behind - might have to remove mine as i have a slight buzzing from somewhere near/ behind the pass door panel 😞

[Si_ST]

this may help

 

[Magicmushroom2005]

Where did you get the window guide from? It their a guide for anything on the fiesta?

[Magicmushroom2005]

On 12/23/2020 at 5:03 PM, Si_ST said:

this may help

 

Shame he misses the window bit out hahah thanks

[Eng_Ahmad1986]

20 hours ago, Magicmushroom2005 said:

Where did you get the window guide from? It their a guide for anything on the fiesta?

This is FORD workshop manual for our mk8 Fiesta

2017-2020 Ford Fiesta 1.0L Ecoboost 6-Speed Workshop Manual - Get Free (cardiagn.com)

if it didn't work try cardiagn.com then select your Brand and Model 🙂 

I shared this worskhop manual in a previous post