Jump to content
Do Not Sell My Personal Information


Guide - 2013 Mk 7.5 (Facelift) Fiesta Zetec S Front Grill Install


Willy
 Share

Recommended Posts

All parts can be obtained from your Ford dealer or at the following sites. Prices vary so shop around for the best deal.

http://www.european-...6bnkglo41ifdnt7

Black Front Grille Set - KITFIETRIM18 - £198

http://www.fordpartsuk.com/shop/ford_fiesta_sporty_grille_kit_from_2012_to_2014_f_KITFIETRIM18.htm

1 (8).jpg

 

 

Black Upper grille - 1778260 - £70:80

http://www.fordpartsuk.com/shop/ford_fiesta_front_upper_grille_2012_f_1778260.htm1 (7).jpg

 

 

Black Lower grille - 1801358 - £79.95 

http://www.fordpartsuk.com/shop/ford_fiesta_front_lower_bumper_grille_2012_f_1801358.htm1.jpg

 

 

Red Upper Grille Set - KITFIETRIM21 - £148 

http://www.fordpartsuk.com/shop/ford_fiesta_grille_upgrade_kit__f_KITFIETRIM21.htm1 (1).jpg

 

 

Red Upper Grille - 1865992 - £67.15 

http://www.fordpartsuk.com/shop/ford_fiesta_upper_grille_with_red_frame_2014_f_1865992.htm1 (3).jpg

 

 

Red Lower Grille - 1884342 - £80.50 

http://www.fordpartsuk.com/shop/ford_fiesta_zetecs_lower_grille_with_red_frame_2014_f_1884342.htm1 (4).jpg

 

 

O/S or D/S Fog Surround - 1777210 - £18.75 

http://www.fordpartsuk.com/shop/ford_fiesta_rh_fog_lamp_bezel_2012_f_1777210.htm1 (6).jpg

 

 

N/S or P/S Fog Surround - 1777211 - £18.75 

http://www.fordpartsuk.com/shop/ford_fiesta_front_fog_lamp_bezel_lh_2012_f_1777211.htm1 (5).jpg


 

 

Air Deflector / Spoiler - 1801362 - £39.99

http://www.fordpartsuk.com/shop/ford_fiesta_front_bumper_aero_foil_black_f_1801362_c_1101.htm

2.jpg

 

 

Rivets - 1555829 - £3.00 for 12
 

http://www.fordpartsuk.com/shop/ford_fiesta_front_bumper_skirt_fitting_kit_from_2012_onwards_f_1802987.htm1.jpg
 

 

Here's the fitting guide.....................

When fitting the grilles fit the lower grille FIRST!!

Fitting the lower grille first will ensure a good tight fit before fitting the upper / larger grille.

If your thinking of removing the bumper then this guide will definitely help. http://www.mountune.com/downloads/Fiesta_ST_IC_install_rev1.0.pdf

Fog Surrounds first

Quite an easy job here which will take you only a few minutes to complete.

First thing to do is remove the old surrounds, it's easier if you take the chrome piece off first and grab in the same area and pull (quite hard) until you can get your other hand under the edge to  gentle pull it off.

Posted Image

That's the hardest bit done, you now should have something like this.
 
Posted Image

Posted Image

Give the exposed area a quick clean then get your nice new surround, Line up the tabs and the slots and push it home, you are now done.

Posted Image


Front Grille .........

When fitting the grilles fit the lower grille FIRST!!

Fitting the lower grille first will ensure a good tight fit before fitting the upper / larger grille.

Ok this one isn't as easy as expected and be prepared to get sore hands.
There's a few ways to do this. A trim tool will come in handy. Use the tool to pry off the chrome  trim first. Place the tool on the inside of the trim and gently remove. 

 

20160321_144017_zpszdvbjymu.jpg

 

Once the chrome trim is off, use the trim tool to release the clips holding the grille on. Give the grille a gentle tug and that should release it from the car.


20160321_144313_zpsnoalwtnz.jpg

 

The other option is to pull the grille from the car starting from one of the corners. Once started gently but firmly pull the rest of the grille from the car. Be warned the grille can break so be prepared.
To avoid any breakages I recommend removing the front bumper using Mountunes guide here. http://www.mountune.com/downloads/Fiesta_ST_IC_install_rev1.0.pdf or using a trim tool.

Posted Image

Next you'll need line your new grille with the slots on the bumper and push them home until you've gone all the way round. You should now have very sore hands but be admiring your hard work.

You should now have very sore hands but be admiring your hard work.
 
Posted Image
 
The lower grille is a very similar fitting 
 
Lower Grill ..........


As the upper grill really, start by pulling off the grill, clean the area before placing your new grill into the empty space.
 
Posted Image
 
Posted Image
 
Push the new grill home and your done 
 
Posted Image
 
Front Spoiler next ...............
 
Start by removing the black rivets from under neath the front bumper, there will be 8 to remove and will require you jacking up the front of the car so that you can get good access with your drill.

Posted Image
 
Once removed you'll need to fish out the old pot rivets. this is a pain but be patient.Next you'll need your new spoiler and rivets.
 
Posted Image
 
Posted Image
 
Place the spoiler in the locating holes under the bumper, insert a rivet where the old ones were, and pop away until all 8 are done and the spoiler is firmly in place.
 
Posted Image
 
Your all done and should now be loving the Zetec S look.

Posted Image

Posted Image

 

untitled.JPG

fog.jpg

20130420_125039.jpg

20130420_125122.jpg

20130420_131544.jpg

PicsArt_1366560659393.jpg

IMG-20130423-WA0004.jpg

IMG-20130423-WA0001.jpg

  • Like 1
Link to comment
Share on other sites


Front Grille .........

Ok this one isn't as easy as expected and be prepared to get sore hands.

First thing to do is pull the Grille from the car starting from one of the corners. Once started gently but firmly pull the rest of the grille from the car. Be warned the grille can break so be prepared.

To avoid any breakages I recommend removing the front bumper using Mountunes guide here.

http://www.mountune.com/downloads/Fiesta_ST_IC_install_rev1.0.pdf

post-5052-0-09306900-1366561595_thumb.jp

Next you'll need line your new grille with the slots on the bumper and push them home until you've gone all the way round. You should now have very sore hands but be admiring your hard work.

post-5052-0-51933400-1366578812_thumb.jp

The lower grille is a very similar fitting :)

Link to comment
Share on other sites

Lower Grill ..........

As the upper grill really, start by pulling off the grill, clean the area before placing your new grill into the empty space.

post-5052-0-76862300-1366749204_thumb.jp

post-5052-0-71858000-1366749215_thumb.jp

Push the new grill home and your done :)

post-5052-0-67053100-1366749259_thumb.jp

Front Spoiler next ...............

Start by removing the black rivets from under neath the front bumper, there will be 8 to remove and will require you jacking up the front of the car so that you can get good access with your drill.

post-5052-0-68366900-1366749383_thumb.jp

Once removed you'll need to fish out the old pot rivets. this is a pain but be patient.

Next you'll need your new spoiler and rivets.

post-5052-0-77269400-1366759827_thumb.jp

post-5052-0-54525900-1366749493_thumb.jp

Place the spoiler in the locating holes under the bumper, insert a rivet where the old ones were, and pop away until all 8 are done and the spoiler is firmly in place.

post-5052-0-02691900-1366749638_thumb.jp

Your all done :) and should now be loving the Zetec S look.

post-5052-0-73842000-1366749744_thumb.jp

  • Like 3
Link to comment
Share on other sites

Nice guide Willy.

Out of interest does that spoiler lip fit the MK7?

Link to comment
Share on other sites

Nice guide Willy.

Out of interest does that spoiler lip fit the MK7?

I know there different shape but can't see why not.

Sizes approximate.

post-5052-0-80053200-1366760081_thumb.jp

Link to comment
Share on other sites


Thanks might consider this.I really want the Mountune carbon one but at £150 its a bit pricey and if I scraped it on a kerb I'd die.

Link to comment
Share on other sites

  • 3 weeks later...

What a great guide willy! I'm looking to upgrade my front grill on my zetec as I really like the zetec S look! wheres the best place to get those parts? Ford dealer? or is there a website that manufactures them?

cheers

Marc.

Link to comment
Share on other sites

Thanks for the info, what would be price difference between the parts man and the European webpage?

Cheers

MarcoZetec13

Link to comment
Share on other sites

Depends how well you get on with them I guess but around 10% off

Link to comment
Share on other sites

  • 1 month later...

Anyone have the Finis code for the bumper itself?

Cheers

Link to comment
Share on other sites

  • 6 months later...
  • 1 month later...

Hi There

I have just ordered a 2014 titanium with 17 inch alloys and full dress up kit in black. I want to put a honeycomb grille on the front and came across your thread. Do you know where i would be able to buy the grille from and do you think a garage would do it for me (being a girl!). Also as its a finance car, i would need to put the old grille back on, is this possible?

Thanks

Link to comment
Share on other sites

All the info you need is in the first post Kia.

I would say order your grille and get your ford dealer to fit it. Your looking at 1 hours labour charge to do the work. Options should be ok as long as you use ford parts. If your not sure ask your dealer for more info.

Link to comment
Share on other sites

  • 2 weeks later...

I got all my parts from my local ford dealer. It took a few days to get all the parts with the exception of the main grill which came from Germany and took a week.

Link to comment
Share on other sites

Hi Willy,

Great guide, just bought the parts from my Ford dealer and plan to install soon, and will very much use your guide for this.

I love the honeycomb grill.

Cheers from Denmark.

Sent from my Nexus 5 using Ford OC mobile app

Link to comment
Share on other sites

  • 2 weeks later...

Hi Willy,

How long did it take you? Thinking about doing it today after work :)

Thanks,

/Mick

Link to comment
Share on other sites

Mick give yourself an hour for the main grille and lower grille, 30 minutes for the fog surrounds and 2 hours for the lower spoiler / splitter.

  • Like 1
Link to comment
Share on other sites

Mick give yourself an hour for the main grille and lower grille, 30 minutes for the fog surrounds and 2 hours for the lower spoiler / splitter.

Thank you for the info Willy :-)

Sent from my Nexus 5 using Ford OC mobile app

Link to comment
Share on other sites

Just finished, I am missing the lower spoiler, it will get done when I can get a hold of a lift :-) thanks for advice Willy!

New honeycomb front

  • Like 1
Link to comment
Share on other sites

  • 3 weeks later...

Hi, could you please link me to the exact ones you ordered? Been looking on the net and it's hard to find, and can't find any at the prices you've stated, thanks

Link to comment
Share on other sites

Hi, could you please link me to the exact ones you ordered? Been looking on the net and it's hard to find, and can't find any at the prices you've stated, thanks

Hey.

Www.europeanparts.net

Check out fiesta MK7.5 and you'll find the parts there, sent from Germany but good quality Ford parts.

Cheers

MarcoZetec13

Sent from my LG-D802 using Ford OC mobile app

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

 Share





×
×
  • Create New...

Forums


News


Membership